MODEL NO. WET2242STA22.0 HP 42 InchLawn Tractor 186832 Rev. 3 6.6.03 JH/MHPRINTED IN U.S.A.®For Parts and Service, contact
10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to
11NOTE: Under certain conditions when tractor is standing idle with the engine running, hot engine exhaust gases may cause “brown ing” of grass. To
12TO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes great er than 15° and do not drive across any slope.• Choose the slowes
13OPERATIONTO START ENGINE (See Fig. 5)When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking t
14MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil
15MAINTENANCEFIG. 9FIG. 8BATTERYYour tractor has a battery charging system which is suf fi cient for normal use. However, periodic charging of the ba
16MAINTENANCEV-BELTSCheck V-belts for deterioration and wear after 100 hours and replace if necessary. The belts are not adjustable. Re place belts if
17MAINTENANCECLEANING• Clean engine, battery, seat, fi nish, etc. of all foreign matter.• Keep fi nished surfaces and wheels free of all gasoli
18SERVICE AND ADJUSTMENTSWARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST-MENTS:• Depress clutch/brake pedal fully and s
19TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 18)The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage
2• Avoid starting or stopping on a slope. If tires lose trac-tion, disengage the blades and proceed slowly straight down the slope.DO NOT:•
20SERVICE AND ADJUSTMENTSFIG. 18TO REPLACE MOTION DRIVE BELT (See Fig. 20)Park the tractor on level surface. En gage parking brake. For as sis tance
21FIG. 20ADJUSTMENT BOLTNEUTRAL LOCK GATEGEARSHIFT LEVERFIG. 21SERVICE AND ADJUSTMENTSTRANSAXLE PULLEYSTA TION ARY IDLERCLUTCHING IDLERENGINE PULLEYCE
22FIG. 23SERVICE AND ADJUSTMENTSREPLACING BATTERY (See Figs. 24 and 25)WARNING: Do not short battery ter mi nals by allowing a wrench or any other ob
23SERVICE AND ADJUSTMENTSENGINETO AD JUST THROTTLE CON TROL CABLE The throttle control has been preset at the factory and ad just ment should not be n
24STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never
25TROUBLESHOOTING POINTSWill not start 1. Out of fuel.
26TROUBLESHOOTING POINTSPROBLEM CAUSE CORRECTION Engine continues to run 1. Faulty operator-safety presence control system.
27REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STASCHEMATICBATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITHEADLIGHTSREMOVABLECONNECTIONSBLACKBLACKB
28REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAELECTRICAL2829262442432727254127274033903082127161652482221
29REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAELECTRICAL1 163465 Battery 12 Volt 25 Amp2 74760412 Bolt Hex Hd
3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl
30REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STACHASSIS AND ENCLOSURES2625586420813208111329208209209209552073331423331421729281251575352545514537337
31REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STACHASSIS AND ENCLOSURES1 174619 Chassis 2 176554 Drawbar3
32REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STADRIVE292811214413839575174757876771251924253353437363562365921255776122272661131851518685523032323052
33REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STADRIVEKEY PARTNO. NO. DESCRIPTION KEY PARTNO. NO. DESC
34REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STASTEERING ASSEMBLY445154595779433243643810401186946468692474726302814142373637381239686767671365858568
35REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STASTEERING ASSEMBLY1 140044X428 Wheel Steering Auto Black2 175131 Axle
36REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAENGINE21OPTIONAL EQUIPMENTSpark Arrester2926254234581062657213143810516105381engine-tecumseh_16333733
37REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STASEAT ASSEMBLYKEY PART NO. NO. DESCRIPTIONKEY PART
38511 16 6923101214WHEELS & TIRESKEY PART NO. NO. DESCRIPTION1 59192 Cap Valve Tire
39REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAMOWER LIFT152016171820201520456231654781211313231321919131313131 159460 Wire Asm
4TABLE OF CONTENTSSAFETY RULES ... 2-3PRODUCT SPECIFICATIONS ...
40REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAMOWER DECK1514131110981668371843031323314614814515045144147147142149545253555634146442124252627228292
41REPAIR PARTSTRACTOR - - MODEL NUMBER WET2242STAMOWER DECK1 165892 Mower Deck Assembly, 42"2 72140506 Bolt
42LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an
43TECUMSEH®Issued January 1980Revised January 1991TECUMSEH®SERVICEPOLICYPOLICYWARRANTYLIMITED WARRANTIESFOR NEW PEERLESS GEAR POWER TRAIN COMPONENTSA.
15 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE O
5CONTENTS OF HARDWARE PACKSteering WheelSeatKeysSlope Sheet(1) Oil Drain Tube (1) Bolt(1) Washer 17/32 x 1-3/16 x 12 Gauge(1) Lock Washer 1/2(1) Larg
6ASSEMBLYTOOLS REQUIRED FOR ASSEMBLYA socket wrench set will make assembly easier. Stan dard wrench sizes are listed.(2) 7/16" wrenches Utilit
7ASSEMBLYFIG. 2TO ROLL TRACTOR OFF SKID (See Op- er a tion section for location and func tion of con trols)• Press lift lever plunger and raise a
8ASSEMBLY✓CHECKLISTBEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PER FOR MANCE AND SATISFACTION FROM T
9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDS
Comments to this Manuals